Gull-wing door
From WOI Encyclopedia Italia
The term gull-wing door is an automotive industry term describing automobile doors which are hinged at the roof. They are so named because, when opened, the doors evoke the image of a seagull's wings.
Conventional car doors are typically hinged at the front-facing edge of the door and allow the door to swing outward from the body of the car.
The most well-known examples of road-cars with gull-wing doors are the Mercedes-Benz 300SL from the 1950s, the Bricklin SV-1 from the 1970s and the De Lorean DMC-12 from the 1980s.
Contents |
Practical considerations
Despite the common misconception that the gull-wing doors are mere stylistic affectations, the design is a very practical one. The advantage is that when properly designed and counterbalanced (for example, the De Lorean), they require little side-clearance to open (about 27.5 cm, or 11" in the De Lorean[1]) and allow much better entrance/egress than conventional doors. This is especially important for vehicles like the De Lorean whose width would make conventional doors awkward to use when the car is in a conventional urban parking space.
Design challenges
Gull-wing doors have a somewhat questionable reputation because of early examples like the Mercedes and the Bricklin. The 300 SL used the door design to allow an unusual chassis design which required a very high door sill and forced the doors to be smaller than would otherwise have been optimal. The Bricklin was a more conventional sized door but the actuation system was problematic in day-to-day use and led to unreliable operation. In addition, there was some concern that in making the door as light as possible, it couldn't provide adequate protection in side-impact accidents. There was, however, no indication that this concern was justified.
The De Lorean solved these problems by using a solid-steel torsion bar (supplied by Grumman Aircraft Engineering Corporation) to counterbalance a full-sized door and then used simple pneumatic struts similar to those found in hatchback cars to open the doors and dampen the movement of the doors.
Other disadvantages of the system were not so easy to address. For example, the gull-wing design makes creating a convertible version of the car virtually impossible since, for optimal efficiency, the hinges must be placed as close to the center of the car as possible. This was never a concern for the De Lorean since no convertible version was ever planned (though there were rumors of a four-door family car based on a front-engine chassis with room for four passengers).
It also makes sealing the car against water leaks more difficult because of the shape and movement path of the door itself. Many De Lorean owners report leakage when taking their vehicles through automated car-washes because of the high-pressure water jets, though in ordinary rainfall the seals were more than adequate.
Similar designs
In addition to the traditional gull-wing doors, there are other unusual door mechanisms - particularly among exotic and expensive cars. Lamborghini uses a design which is a hybrid of the conventional and gull-wing design which is generally referred to as a "scissor", "jack-knife" in which the door is still hinged at the front but swings upward from the car while staying parallel with the edge.
The McLaren F1 roadcar and Mercedes-Benz SLR use a variant of this system called Butterfly doors. The doors are hinged at the front similar the scissor doors but the hinges are placed higher up on the A-pillar, allowing the door to pivot both up and out. This increases the ability of the door to move out of the way of the car's occupants but does not prevent a convertible version. The Toyota Sera was a limited-release car designed exclusively for the Japanese market which used this design. Due to its unusual design, some enthusiasts in Australia, New Zealand and England have privately imported the cars. It is available only in right-hand drive configuration.
Koenigsegg uses a "dihedral synchro-helix" system for their vehicles which seems to combine the advantages of all the designs, though with considerably more mechanical complexity.
The BMW Z1 used a novel design in which its doors were not hinged at all but rather retracted vertically into the chassis, leaving an empty (though unusually high) sill.
The kit car Nova/Sterling [2] [3] also known as Purvis Eureka [4] in Australia used a special type of door, actually a lifting canopy, on several of their models where the entire top section of the car was opened. The Saab Aero-X used a similar design, but had doors as well.
List of automobiles
The following is a (partial) list of production and kit automobiles with gull-wing and other unusual door designs:
Production cars
- Autozam AZ-1 a Keicar
- BMW Z1 (the Z1 used unhinged doors that lowered into the chassis)
- Bricklin SV-1 (gull-wing)
- Bristol Fighter (gull-wing)
- De Lorean DMC-12
- Koenigsegg CC8S, CCR and CCX (dihedral synchrohelix)
- Lamborghini ("scissor" or "jack knife" doors)
- McLaren F1
- Mercedes-Benz 300SL, SLR McLaren
- Saleen S7
- Toyota Sera
- Porsche 917 "Panzer" (racecar)
- Ferrari Enzo Ferrari
Kit cars
- AMT Piranha
- Bradley GTII
- Dare DZ
- Eagle SS Mk1
- Fiberfab Aztec 7, also known as Charger II
- Foers Ibex
- GP Talon
- Isdera Commendatore 112i
- Innes Lee Scorpion K19
- Replicar Cursor
- Isetta
- RPB GT
See also
References
| Articles relating to Automobile configurations | |
|---|---|
| Car body style and classification | 2 plus 2 | Antique car | Cabrio coach | Cabriolet | City car | Classic car | Compact car | Compact performance car | Compact SUV | Convertible | Coupé | Coupé convertible | Coupe Utility | Crossover SUV | Custom car | Drophead coupe | Fastback | Full-size car | Grand tourer | Hardtop | Hatchback | Hot hatch | Hot rod | Large family car | Leisure activity vehicle | Liftback | Limousine | Luxury car | Microcar | Mid-size car | Mini SUV | Minivan | Multi-purpose vehicle | Muscle car | Notchback | Personal luxury car | Pickup truck | Retractable hardtop | Roadster | Sedan | Saloon | Small family car | Sport compact | Sports car | Sport utility vehicle | Spyder | Station wagon | Estate car | Supermini | Targa top | Taxicab | Touring car | Town car | T-top | Ute | Van | Voiturette |
| Specialised vehicles | Gyrocar | Flying car. Amphibious vehicle |
| Fuel technologies | Internal combustion engine | Electric vehicle | Neighborhood electric vehicle | Hybrid vehicle | Battery electric vehicle | Hydrogen vehicle | Fuel cell | Plug-in hybrid electric vehicle | Steam car | Alternative fuel cars | Biodiesel | Gasohol | Ethanol | LPG (Propane) | Homogeneous Charge Compression Ignition | Liquid Nitrogen | Gasoline Direct Injection |
| Driven wheels | Four-wheel drive | Front-wheel drive | Rear-wheel drive | All-wheel drive | Two-wheel drive |
| Engine positioning | Front engine | Rear engine | Mid engine |
| Layout | FF layout | FR layout | MR layout | MF layout | RR layout |
| Engine configuration | Internal combustion engine | Straight-6 | V engine | Wankel engine | Reciprocating engine | Inline engine | Flat engine | Flathead engine | Diesel engine | Two-stroke cycle | Four-stroke cycle | Pushrod engine | Straight engine | H engine | Turbodiesel | Hybrid vehicle | Rechargeable energy storage system | Electric vehicle | Hydrogen vehicle |
| Body | Framework | A-pillar | Bumper | Cabrio coach | Chassis | Crumple zone | Body-on-frame | Dagmar bumpers | Fender | Fender skirts | Grille | Hood | Hood scoop | Monocoque construction | Pontoon fenders | Quarter panel | Shaker scoop | Spoiler | Subframe | Tonneau |
| Doors | Butterfly doors | Gull-wing door | Scissor doors | Suicide door | |
| Glass | Sunroof | Greenhouse | Windshield | |
| Other | Antenna ball | Hood ornament | Japan Black paint | Nerf bar | Truck accessory | Bumper sticker | |
| Exterior Equipment | Lighting | Daytime running lamp | Headlamp | Headlight styling | Hidden headlamps | Retroreflector | Sealed beam | Trafficators | High intensity discharge |
| Other | British car number plates | Distance sensor | US and Canadian license plates | Vanity plate | Vehicle registration plate | Windscreen wiper | Windshield washer fluid | |
| Car engine | Air/Fuel | Air filter | Automatic Performance Control | Blowoff valve | Boost | Boost controller | Butterfly valve | Carburetor | Charge cooler | Centrifugal type supercharger | Cold air intake | Engine management system | Engine Control Unit | Forced induction | Front mounted intercooler | Fuel filter | Fuel injection | Fuel pump | Fuel tank | Gasoline direct injection | Indirect injection | Intake | Intercooler | Manifold | Manifold vacuum | Mass flow sensor | Naturally-aspirated engine | Ram-air intake | Scroll-type supercharger | Short ram air intake | Supercharger | Throttle body | Top mounted intercooler | Turbocharger | Turbocharged Direct Injection | Twin-turbo | Variable Length Intake Manifold | Variable geometry turbocharger. Warm air intake |
| Exhaust | Catalytic converter | Emissions control devices | Exhaust pipe | Exhaust system | Glasspack | Muffler | Oxygen sensor | |
| Cooling | Aircooling | Antifreeze | Ethylene glycol | Radiator | Thermostat | |
| Ignition system | Starter | Car battery | Contact breaker | Distributor | Electrical ballast | Ignition coil | Lead-acid battery | Magneto | Spark-ignition | Spark plug | |
| Other | Balance shaft | Block heater | Crank. Cam | Camshaft | Connecting rod | Combustion chamber | Crank pin | Crankshaft | Crossflow cylinder head | Crossplane | Desmodromic valve | Engine knocking | Compression ratio | Crank sensor | Cylinder | Cylinder bank | Cylinder block | Cylinder head | Cylinder head porting | Dump valve,Engine balance | Oil filter | Firing order | Freeze plug | Gasket | Head gasket | Hypereutectic piston | Hydrolock | Lean burn | Main bearing | Motor oil | Multi-valve | Oil sludge | Overhead camshaft | Overhead valve | PCV valve | Piston | Piston ring | Pneumatic valve gear | Poppet valve | Power band | Redline | Reverse-flow cylinder head | Rocker arm | Seal | Sleeve valve | Starter ring gear | Synthetic oil | Tappet | Timing belt | Timing mark | Top dead centre | Underdrive pulleys | Valve float | Variable valve timing | |
| Interior equipment | Instruments | Backup camera | Boost gauge | Buzzer | Car computer | Carputer | Check Engine light | Fuel gauge | Global Positioning System | Idiot light | Navigation system | Odometer | Speedometer | Tachometer | Trip computer |
| Controls | Bowden cable | Cruise control | Electronic throttle control | Hand brake | Manettino dial | Steering wheel | Throttle | Gear stick | |
| Motor vehicle theft deterrence | Car alarm | ESITrack | Immobiliser | Klaxon | Vehicle tracking system | VIN etching | |
| Passenger safety & seating | Airbag | Armrest | Automatic seatbelt | Bench seat | Bucket seat | Child safety lock | Dicky seat | Passive safety | Rumble seat | Seat belt | |
| Other | Air conditioning | Ancillary power | Car audio | Car phone | Center console | Dashboard | Motorola connector | Power window | Rear-view mirror | TripSense | |
| Powertrain | Wheels and Tires | All-terrain tyre | Bias-ply tire | Contact patch | Custom wheel | Drive wheel | Hubcap | Magnesium alloy wheel | Mud-terrain tyre | Paddle tires | Radial tire | Rostyle wheel | Run flat tires | Schrader valve | Slick tire | Spinner | Tire code | Tread | Treadwear rating | Whitewall tire | Wire wheels |
| Transmission | Automatic transmission | Clutch | Continuously variable transmission | Differential | Driveshaft | Electrorheological clutch | Epicyclic gearing | Fluid coupling | Fully-automatic transmission | Gear stick | Gearbox | Hydramatic | Limited slip differential | Locking differential | Manual transmission | Roto Hydramatic | Saxomat | Semi-automatic transmission | Semi-automatic transmission | Super Turbine 300 | Tiptronic Torque converter | Transmission (mechanics) | Transmission Control Unit | Turbo-Hydramatic | Universal joint | |
| Steering | Ackermann steering geometry | Anti-lock braking system | Camber angle | Car handling | Caster angle | Oversteer | Power steering | Rack and pinion | Toe angle | Torque steering | Understeer | |
| Suspension | Axle | Beam axle | Coil spring | De Dion tube | Double wishbone | Electronic Stability Control | Hydragas | Hydrolastic | Hydropneumatic suspension | Independent suspension | Kingpin | Leaf spring | Live axle | MacPherson strut | Multi-link suspension | Panhard rod | Semi-trailing arm suspension | Shock absorber | Sway bar | Swing axle | Torsion beam suspension | Transaxle | Trailing arm | Unsprung weight | Watt's linkage | Wishbone suspension | |
| Brakes | Anti-lock braking system | Disc brake | Drum brake | Hand brake | Hydraulic brake | Inboard brake | Brake lining | Brake fade | Brake fluid | Hydraulic fluid | Brake bleeding | Engine braking | Electronic brakeforce distribution | Regenerative brake |
